Commercial boiler flue systems - hamworthy-heating.com

Modern condensing boilers generate condensate from the flue gases at a rate of around 13 litres per hour for a 100kW boiler, therefore flue systems must be water tight and pressure tight, and designed to drain the condensate back into the boiler.

Read More

ENERGY STAR Most Efficient 2019 Boilers | Products

91.5% AFUE Condensing Oil Fired Boiler features a down flue heat exchanger constructed of mild and stainless steel. This flue passage design slows the exhaust gases, maximizing heat transfer and efficiency while yielding ultra low stack temperatures and quiet operation.

Read More

Back to Basics: Venting for Gas-Fired Boilers | 2003-06-04

Jun 04, 2003· Venting Systems. As the efficiency of a boiler goes up, the temperature of the flue gases go down, and the gases are more likely to condense in the flue. When combustion efficiency exceeds approximately 83%, there is a good possibility that the flue products will condense.

Read More

Condensing Hot Water Boilers - Parker Boiler Co

Parker TC steel boilers are triple flue pass, condensing boilers for installation in a boiler room. While they are designed primarily for central heating purposes, in conjunction with a suitable storage cylinder they can also be used to produce domestic hot water.

Read More

Boiler Stainless Steel Exhaust Flue Stack | HVAC Heating

Boiler Stainless Steel Exhaust Flue Stack. This change of state of flue gases in the vent pipe depends on many different variables like length of run, the efficiency of the boiler or furnace, type of material used in the flue, the temperature of the flue, and ambient temperature outside and where the flue pipe is

Read More

Condensing Boiler Regulations - Boiler Guide

It means all new boilers installed in a property have to be condensing boilers. Why You Should Have a Condensing Boiler. Condensing boilers have two internal heat exchangers which means that the heat lost to the surroundings, especially through the flue, is decreased. This makes them highly efficient.

Read More

DuraVent, Inc. : PolyPro® - Flue & Venting Products

PolyPro is a polypropylene vent pipe for use with ANSI Category II and IV gas-burning appliances, including highefficiency water heaters, condensing boilers and warm air furnaces. Poly Pro is listed by Intertek to the ULC S636 standard in Canada as a Class IIA, IIB and IIC vent system suitable for exhaust temperatures up to 230°F / 110°C, and

Read More

Crest Condensing Boiler | Lochinvar

The patented Wave configuration creates turbulence as flue gas products flow down the tube, scrubbing the energy from the flue products. The Wave design enhances the life of the heat exchanger by allowing the tubes to flex so they operate stress free with none of the adverse effects suffered by traditional fire-tube boilers.

Read More

Why do I need to move my boiler flue? - TheGreenAge

Sounds like your neighbours have ignored the Governments Guide to the Condensing Boiler Installation Assessment Procedure for Dwellings. This states that a condensing boiler flue should be a minimum of 2.5 metres from a facing wall, fence, building or property boundary.

Read More

Conventional vs. Condensing Boilers - AccuServ Heating and

The condensing boiler condenses the vapors within the boiler so as to recapture the heat lost in flue gasses and has the beneficial side-effect of preventing corrosion resulting from condensed vapors.

Read More

Flue Condensation Problems - HVAC Heating & Cooling

Flue Condensation Problems - This picture shows a furnace flue with condensation problems. Flue condensation problems are caused by hot gases cooling too quickly in the flue. As the hot gasses, cool moisture in the gases condenses and start dripping back down the flue.

Read More

Venting a condensing boiler through chimney? Heating

Venting a condensing boiler through chimney? A heating contractor is suggesting that I have installed a Baxi Luna HT condensing modulating boiler. Because of the configuration of my basement, the boiler will be installed near an exterior wall that also has a wrap-around porch.

Read More

What are Condensing & Non-Condensing Boilers? | Mistral

New non-condensing boilers. Our new non-condensing boilers, which are minimum European 3 star rated, are 89% efficient* as opposed to condensing boilers achieving from 90% which can then be classed as A rated products. This range is as close as you can get to a condensing boiler and has a new ERP rating at Seasonal Efficiency of up to 87%.

Read More

Are oil-fired, condensing boilers worth it? Heating Help

The flue gas exits the burner tube at about 800'F and then runs the 3 pass gamut which has 8 baffle plates to slow the flue gases down and the flue gases finally exit the boiler at about 300'F. If you have an exterior clay tile masonry chimney, you should line it with a stainless steel liner.

Read More

What is a Condensing Gas Boiler? | U.S. Boiler Company

Traditional vs. Condensing Gas Boilers. These boilers are vented to the outside via a chimney flue or vent pipe. Traditional boilers typically operate at higher temperatures, which means that a portion of heat is vented to the outside during the combustion process. Depending upon its age and type, a traditional non-condensing boiler will typically be 80% to 85% efficient.

Read More

Total System Efficiency with Condensing Boilers

In condensing boilers, there is a direct correlation between increasing condensation of the flue gas and boiler efficiency gains. Boilers are closed pressure vessels

Read More

Explaining Boiler Flue Regulations | Boiler Guide

Condensing boilers are highly efficient units that have 2 internal heat exchangers meaning that less heat is lost through the flue. When a non-condensing boiler is replaced with a condensing boiler, the different flue arrangements could mean that the current flue has to be relocated.

Read More

Condensing boiler - Wikipedia

In particular, the problem of 'pluming' arose with early installations of condensing boilers, in which a white plume of condensed vapour (as minuscule droplets) becomes visible at the outlet flue. Although unimportant to boiler operation, visible pluming was an aesthetic issue that caused much opposition to condensing boilers.

Read More

Crest Condensing Boiler | Lochinvar

The patented Wave configuration creates turbulence as flue gas products flow down the tube, scrubbing the energy from the flue products. The Wave design enhances the life of the heat exchanger by allowing the tubes to flex so they operate stress free with none of the adverse effects suffered by traditional fire-tube boilers.

Read More

Busting The Myths About Condensing Boilers | GreenMatch

Jan 24, 2019· Condensing boilers are water heating appliances which run on gas or oil. As the name implies, the boilers functioning principle is based on water vapor condensation - a process that allows for more heat extraction from the fuel that is used. It does so by using the previously untapped heat

Read More